Difference between revisions of "Lime plaster"

Latest revision as of 09:22, 20 September 2010

This article contains too much jargon and may need simplification or further explanation. Please discuss this issue on the talk page, and/or remove or explain jargon terms used in the article. Editing help is available. (February 2010)

This article needs auditing for compliance with the Manual of Style. Please improve this article if you can. (May 2010)

Lime plaster is type of plaster composed of hydrated lime, sand and water. Lime plaster is similar to Lime mortar, the main difference is the based on use rather than composition. Traditional lime plaster contains also horse hair to reinforce plaster.

It is sold as 'bagged' powder or hydrated lime; or is available as lime putty. Lime putty generally being considered more suitable for pure lime application.

Non-hydraulic lime is the most commonly used and known lime, also called (high) calcium lime or air lime, as it sets only by reaction with CO₂ in the air and will not set until dry. This causes limitations in construction use as the lime can remain soft for months or years. Non-hydraulic lime can only set through carbonation (re-absorption of CO₂).

Hydraulic lime and hydrated lime must not be confused. Hydrated lime is merely a form in which lime can be supplied (as opposed to quicklime or lime putty); while 'hydraulic' refers to a water resistancy characteristic of the lime.

Safety issues

Lime is an extremely caustic material when wet, with a pH of 12. (Lime becomes pH neutral when carbonated). As such, the use of protective goggles, gloves, and clothing are necessary when working with lime. Clean water should also be kept readily accessible for first aid purposes when working with lime in case of accidental eye or skin exposure.

• First aid for cases of skin exposure to lime involves neutralization with very mild acid such as vinegar or lemon juice.
• First aid for cases of accidental eye exposure consists of repeatedly flushing the eye for several minutes with fresh water. Medical attention should be sought in such cases.^[1]

Historical use in the arts

One of the earliest examples of lime plaster dates back to the end of the eighth millennium BC. Three statues were discovered in a buried pit at 'Ain Ghazal in Jordan that were sculpted with lime plaster over armatures of reeds and twine. They were made in the pre-pottery neolithic period, around 7200 BC. The fact that these sculptures have lasted so long is a testament to the durability of lime plaster.^[2]

Historical uses in Building

• Some of the earliest known examples of lime use for building purposes are in early Egyptian buildings (primarily monuments). Some of these examples in the chambers of the pyramids, which date back to around 2000 B.C., are still hard and intact.
• Archaeological digs carried out on the island of Malta have shown that in places like Tarxien and Hagar, lime stucco was also used as a binder to hold stone together and as well as for decoration at sites dating back as far as 3000-2500 B.C.
• At el-Amarna, a large pavement on brick was discovered that dates back to 1400 B.C. It was apparently the floor of part of the harem of King Amenhotep IV.^[3]
• Ancient Chinese used Suk-wui (the Chinese word for slaked lime) in the construction of The Great Wall of China.
• The Aztec Empire and other Mesoamerican civilizations used lime plaster to pave streets in their cities.^[4] It was also used to coat the walls and floors of buildings.

See also

References

Further reading

Cedar Rose Guelberth and Dan Chiras, The Natural Plaster Book: earth, lime and gypsum plasters for natural homes'

J.N. Tubb, Canaanites, London, The British Museum Press, 1998

Stafford Holmes, Michael Wingate, Building With Lime: A Practical Introduction, Intermediate Technology Publications Ltd,

External links

• General Guidelines for Working with Lime Mortar and Limewash, Ellen Hagsten,Traditional & Sustainable Building, March 2007
• British Museum: Lime Plaster Statues
• [http://www.jstor.org/pss/530161 Yuval Goren, Paul Goldberg, Peter W. Stahl and Udo H. Brinker

1. ↑ Hagsten, Ellen. General Guidelines for Working with Lime Mortar and Limewash, Traditional & Sustainable Building, March 2007
2. ↑ J.N. Tubb, Canaanites, London, The British Museum Press, 1998
3. ↑ Cowper, Ad. Lime and Lime Mortars, first published for the Building Research Station by HM Stationery Office, London, 1927
4. ↑ ISBN 978-0-500-28714-9